Wednesday, September 2, 2015

Hidden in the W124 bonnet



Shoud the W124 owners take pride in their cars being able to be used illegal courier for smuggling humans?

Though the car make was not mentioned in the original article, one can clearly identify with the wipers, fuse-box and coolant reservoir..

North African man almost slipping past Guardia Civil Border Police.
Another illegal migrant was hidden behind the rear seat of the same car.

Good choice of car...

Rejoice, as the W124 was not just well-liked by Luc Besson.


Wednesday, June 11, 2014

Keyless entry replacement on the W124



My wireless entry failed recently due to the siren wiring short circuiting and thus I am no longer able to use my remote to unlock or lock the doors.

Not too much of a problem as I'd always wanted to replace the system as the range of the old one was quite limited.

I had bought a keyless entry system from Aliexpress since 2 years ago and had no good reason to install it until a week ago when it rained so heavily that it shorted my siren +12V wire to ground and rendered the old keyless entry system useless.


http://www.aliexpress.com/item/Free-Shipping-CF904-Keyless-Entry-Car-Alarm-System-With-Flip-Key-And-Logo-Trunk-open-function/493509728.html

This was the system that was purchased and the instruction manual looks like this.





Honestly, even for an electrical engineer, the instructions were quite useless...

Then I found help,at Peachparts forums, where many classic Mercedes owners, contribute technically to helping other owners, in this thread.

Monday, June 2, 2014

Flickering headlamp aka dash bulb warning light



If your W124 is experiencing a dash bulb warning light that comes on and off, it may be a hint that your headlamp connectors is not as tight as it should be anymore.



If the cause is not an actual faulty bulb, it is likely a loose connector.

This connector is one of the causes of a flickering bulb warning on your dashboard.

W124 Euro Headlamp Connector
It is the connector that connects to the headlamp.


After 20 or more years, the connectors might be slightly deformed and may not latch as well onto the male pins. A simple solution will be to add a layer of material on the non-conducting pin as shown below. This will introduce some friction and tightness onto the way the plug connects and will also increase the contact of the conducting pins. The material used was a 5mm diameter heat shrink.


DIY increase contact and better latch for headlamp connector


If this had solved your issues with the dash warning indicator, do share with other W124 owners!


Thursday, March 13, 2014

Update #1 on Airflow potentiometer replacement project



Following my post about replacing the airflow potentiometer with a modern alternative, here are some updates

Parts are in.

Simulated input vs output testing.

Using a truck throttle position sensor to vary the input signal and created the output signal.

Using PWM to drive a RC circuit to achieve an analog signal to be seen by the ECU correctly.

The results are quite pleasing. Achieving less than 10ms of delay between the actual response of the output signal mirroring the input PWM.

Click to enlarge to see the 2 lines more clearly

The best way to reduce the haze is to drive



Every car is equipped with an intake air filter.

The engine draws in filtered air, combustion occurs, carbon dioxide and water comes out of the exhaust.

So technically speaking, the dust in the hazy air is trapped by your intake air filter.

Dirty hazy air goes in, carbon dioxide and water comes out.

The perfect environment air filtration device for the haze that we are experiencing now.

There's your lousy excuse to bring your W124,W201,W126,W140,R129s etc for a drive.

And if the missus asks, show her this page!

http://www.channelnewsasia.com/news/singapore/haze-returns-to-singapore/1024520.html

http://sg.news.yahoo.com/haze-in-singapore-worsens-as-3-hour-psi-reading-hits-84-141938058.html

http://yourhealth.asiaone.com/content/singapore-experiences-slight-haze-psi-rises-64


Share if you like this article

Monday, March 3, 2014

Marshall Protocol Explanation and Location



Bought a "Mobius" action camera and created a small video of my journey to the weekly Marshall Protocol meetup for Singapore W124 owners group in Facebook .


Video is best viewed using desktops/laptops to see the annotations.
Annotations will not appear in mobile devices viewing this video

For the W124 owners in Singapore unaware of what is Marshall Protocol, it is a weekly gathering of classic Mercedes Benz owners such as the W124,W201,W126,R129 etc.